刘建国,黄军,余婷,武丽荣,郭丽芳,马朴.多元醇酯水性剥离剂的氧化稳定性研究[J].中国造纸,2023,42(10):78-84 本文二维码信息
二维码（扫一下试试看！）
多元醇酯水性剥离剂的氧化稳定性研究
Study on Oxidative Stability of Polyol Ester Water-based Release Agents
收稿日期：2022-12-08  
DOI：10.11980/j.issn.0254-508X.2023.10.011
关键词:  生活用纸  多元醇酯  水性剥离剂  氧化稳定性  挥发性成分
Key Words:tissue paper  polyol ester  water-based release agent  oxidative stability  volatile component
基金项目:
作者单位邮编
刘建国 山东公用环保科技集团有限公司,山东济宁,272000 272000
黄军* 济宁南天农科化工有限公司,山东济宁,272200 272200
余婷 济宁南天农科化工有限公司,山东济宁,272200 272200
武丽荣 济宁南天农科化工有限公司,山东济宁,272200 272200
郭丽芳 济宁南天农科化工有限公司,山东济宁,272200 272200
马朴 济宁南天农科化工有限公司,山东济宁,272200 272200
摘要点击次数: 3322
全文下载次数: 1900
摘要:本研究以甘油三油酸酯（GTO）和三羟甲基丙烷三油酸酯（TMPTO）为原料分别制备水性剥离剂，通过酸价、过氧化值和气相色谱-质谱联用技术对其氧化稳定性进行研究。结果表明，在相同条件下，GTO水性剥离剂的氧化程度低于TMPTO水性剥离剂；氧化后GTO水性剥离剂的挥发性成分相对含量增长量（124.5）显著小于TMPTO水性剥离剂的挥发性成分相对含量增长量（613.9），其中醛类（占比72%~84%）是最主要的挥发性成分。因此，GTO水性剥离剂的氧化稳定性优于TMPTO水性剥离剂。此外，原料的品质和氧化稳定性是影响水性剥离剂氧化程度的主要因素。
Abstract:In this study， glycerol trioleate （GTO） and trimethylolpropane trioleate （TMPTO） were used as raw materials to prepare water-based release agents respectively， the oxidative stabilities of these two water-based release agents were studied by acid value， peroxide value and gas chromatography-mass spectrometry. The results showed that under the same condition， the oxidation degree of GTO water-based release agent was lower than that of TMPTO water-based release agent， the increase of the relative content of volatile components after oxidation was significantly less of GTO water-based release agent （124.5） than that of TMPTO water-based release agent （613.9）， and aldehydes （covering 72%~84%） were the most major volatile components. Therefore， the oxidative stability of GTO water-based release agent was better than that of TMPTO water-based release agent. In addition， the quality and oxidative stability of raw materials were the main factors affecting the oxidation degree of water-based release agent.
查看全文   HTML   查看/发表评论  下载PDF阅读器