| 李欢,唐小雪,康金岭,李宇飞,陈飞程,柴精精,彭罡星,王建民,周利军,王迅.卷烟纸参数对卷烟锥高的影响[J].中国造纸,2025,44(3):70-75 |
二维码（扫一下试试看！） |
| 卷烟纸参数对卷烟锥高的影响 |
| Effect of Cigarette Paper Parameters on Cigarette Cone Height |
| 收稿日期：2024-09-20 |
| DOI：10.11980/j.issn.0254-508X.2025.03.009 |
| 关键词: 卷烟纸 锥高 均匀实验 卷烟燃烧锥 |
| Key Words:cigarette paper cone height uniformity test cigarette combustion cone |
| 基金项目:广西中烟工业有限责任公司科技创新项目（GXZYCX2023A006）。 |
| 作者 | 单位 | 邮编 | | 李欢 | 广西中烟工业有限责任公司柳州卷烟厂,广西柳州,545001 | 545001 | | 唐小雪 | 广西中烟工业有限责任公司技术中心,广西南宁,530001 | 530001 | | 康金岭 | 广西中烟工业有限责任公司柳州卷烟厂,广西柳州,545001 | 545001 | | 李宇飞* | 广西中烟工业有限责任公司柳州卷烟厂,广西柳州,545001 | 545001 | | 陈飞程 | 广西中烟工业有限责任公司物流中心, 广西南宁,530001 | 530001 | | 柴精精 | 广西中烟工业有限责任公司柳州卷烟厂,广西柳州,545001 | 545001 | | 彭罡星 | 广西中烟工业有限责任公司柳州卷烟厂,广西柳州,545001 | 545001 | | 王建民 | 郑州轻工业大学烟草科学与工程学院,河南郑州,450000 | 450000 | | 周利军 | 山东中烟工业有限责任公司青岛卷烟厂,山东青岛,266100 | 266100 | | 王迅 | 山东中烟工业有限责任公司青岛卷烟厂,山东青岛,266100 | 266100 |
|
| 摘要点击次数: 2251 |
| 全文下载次数: 1009 |
| 摘要:为了探究卷烟纸参数对燃烧锥高的影响规律，按照均匀实验设计原则，选取定量、透气度等6项卷烟纸参数，卷制了12种不同参数水平的卷烟样品，并进行了单因素方差分析与回归分析。结果表明，12种不同卷烟纸参数组合对应的卷烟锥高介于7.958~10.455 mm，相对标准偏差介于2.5%~11.7%；透气度、钠钾比、碳酸镁用量、助燃剂用量4项卷烟纸参数综合作用可解释锥高变化的94.0%，是影响卷烟锥高的主要因素，定量、酸根类型是影响锥高的次要因素；主要因素对锥高影响较小时，卷烟锥高较低，有利于降低燃烧锥落头倾向。 |
| Abstract:In order to explore the influence of cigarette paper parameters on combustion cone height， six cigarette paper parameters including quantitative and air permeability were selected according to the principle of uniform experimental design. Twelve cigarette samples with different parameter levels were rolled and subjected to one-way analysis of variance and regression analysis. The results showed that the cigarette cone heights corresponding to 12 different combinations of cigarette paper parameters ranged from 7.958 to10.455 mm， with relative standard deviation ranging from 2.5% to 11.7%. The comprehensive effect of four cigarette paper parameters， including breathability， sodium potassium ratio， magnesium carbonate addition， and combustion assisting dose， could explain 94.0% of the variation in cone height， which was the main factor affecting cigarette cone height. Quantification and acid radical type were secondary factors affecting cone height. When the main factor had a small impact on cone height， the cone height of cigarettes was lower， which was beneficial for reducing the tendency of combustion cone to fall off. |
| 查看全文
HTML
查看/发表评论 下载PDF阅读器 |
|
|
|