万金泉,杨　静,马邕文,王　艳,郭文杰.采用生物酶提高瓦楞原纸强度的研究[J].中国造纸,2011,30(3):6-10 本文二维码信息
二维码（扫一下试试看！）
采用生物酶提高瓦楞原纸强度的研究
Pilot Enzymatic Treatment of Corrugating Medium
收稿日期：  
DOI：10.11980/j.issn.0254-508X.2011.03.002
关键词:  漆酶  OCC浆  瓦楞原纸  环压指数  保水值
Key Words:laccase  OCC pulp  corrugating medium  ring crush index  WRV
基金项目:本课题由以下项目提供资金支持：国家863项目（2007AA03Z433）；广东省重点科技攻关项目（2008A030202008）；广东省科技计划项目（2008B030302035）。
作者单位
万金泉1,2 1.华南理工大学制浆造纸工程国家重点实验室,广东广州,510640；2.华南理工大学环境科学与工程学院,广东广州,510006 
杨　静1 1.华南理工大学制浆造纸工程国家重点实验室,广东广州,510640 
马邕文1,2 1.华南理工大学制浆造纸工程国家重点实验室,广东广州,510640；2.华南理工大学环境科学与工程学院,广东广州,510006 
王　艳2 2.华南理工大学环境科学与工程学院,广东广州,510006 
郭文杰2 2.华南理工大学环境科学与工程学院,广东广州,510006 
摘要点击次数: 8092
全文下载次数: 2508
摘要:采用漆酶-组氨酸的组合方式处理OCC浆，并先后在实验室和纸厂研究此生物处理方式对瓦楞原纸性能的影响。实验室小试研究结果表明，当漆酶和组氨酸的用量分别为0.90 U/g和1.0%（对绝干浆）时，成纸的干湿环压指数分别提高了22.9%和30.3%。中试结果也表明，漆酶和组氨酸用量分别为0.225 U/g和0.10%时，成纸干湿环压指数分别提高14.9%和26.4%，纵横向抗张指数分别提高8.0%和10.7%，耐破指数提高16.4%。同时生物处理在促进纤维分丝帚化方面也有明显效果，经处理的纤维保水值上升了40个百分点，纤维平均孔径和比表面积分别提高了1.1%和5.1%，并且浆料中羧基含量也提高了35.4%。
Abstract:In this paper, the influence of laccase-histidine on OCC fiber proterties was studied both in laboratory and mill. The laboratory results showed that when the amounts of laccase and histidine were 0.90 U/g and 1.0% respectively. The dry and wet ring crush index of papersheet increased by 22.9% and 30.3% compared with the control sample. Furthermore, the pilot test results also showed that when the amounts of laccase and histidine were 0.225 U/g and 0.10% (on oven dried pulp), the dry and wet ring crush index of papersheet increased by 14.9% and 26.4%, the longitudinal and cross tensile index increased by 8.0% and 10.7%, and brusting index increased by 16.4%, correspondingly. Besides, fibrillation was greatly developed and water retention value (WRV) increased by 37.5%. At the same time, the average pore size of fiber wall, specific surface area and carboxy group content increased by 1.1%, 5.1% and 35.4% respectively.
查看全文   HTML   查看/发表评论  下载PDF阅读器